地面弥雾机与六旋翼植保无人机在芒果冠层中雾滴沉积性能对比

doi:10.12133/j.smartag.SA202207007

摘要/Abstract

摘要：

为解决芒果园传统植保作业中农药用量大、施药不均匀、作业效率低等问题，并构建智慧芒果园，本研究对比了地面弥雾机和六旋翼植保无人机两种果园施药机具在芒果冠层中的药液雾滴沉积性能。将芒果冠层分为上中下层，以柠檬黄为示踪剂，使用高清相纸与滤纸采集药液雾滴，通过图像处理等手段分析雾滴沉积分布均匀性。试验结果表明，植保无人机在芒果树上部冠层叶片表面的雾滴覆盖率显著高于地面弥雾机，在其余冠层部位，两种施药机具在叶片表面药液无显著差异覆盖；植保无人机处理组叶片正反面平均覆盖率均为地面弥雾机的1.5~2倍，对叶片背面的防治优于地面弥雾机。地面弥雾机处理组叶片正面雾滴密度显著高于植保无人机，叶片背面无显著差异，植保无人机处理组正反面均未满足低量喷雾20个/cm2的病虫害防治要求。地面弥雾机药液沉积集中在中下冠层（61.1%），植保无人机集中在上部冠层（43.0%），冠层内部沉积比例地面弥雾机（48.6%）＞植保无人机（25.5%），但地面弥雾机在冠层上部沉积能力不足，沉积占比仅为17%。研究表明，相较于植保无人机，地面弥雾机适用于芒果冠层中下部及内部病虫害防治，同时该机具较高的雾滴覆盖密度在喷洒杀菌剂时也有明显优势，植保无人机适用于针对芒果上部冠层如蓟马、炭疽等易发于外部花絮的病虫害防治。

关键词: 智慧芒果园, 弥雾机, 植保无人机, 雾滴沉积分布均匀性, 病虫害防治

Abstract:

In order to solve the problems of pesticides abuse, nonuniformity deposition and low operating efficiency, build up the smart mango orchard, sedimentary properties of liquids in mango canopy of two orchard pesticide machinery, i.e., orchard caterpillar mist sprayer and six-rotor unmanned aerial vehicle (UAV) of were compared. Mango canopy was divided into upper, middle and lower canopy, tartrazine wsa selected as the tracer, high-definition printing paper and filter paper were used to collect pesticide droplets, the image processing methods such as deposition distribution uniformity were used to analyze the droplets. The experimental results showed that, for the surface droplets coverage rate of upper canopy leaf, unmanned aerial vehicle (UAV) was significantly higher than the cartipillar mist sprayer, there was no significant difference for the middle and lower canopy leaf. The the average coverage rate of both the front and back of leaves in UAV treatment group were 1.5~2 times for cartipillar mist sprayer, and got more deposition in back of leaves compare with caterpillar mist sprayer. The density of droplets on the front of the leaves of the mist sprayer treatment was significantly higher than that of the UAV treatment, but there was no significant difference on the back of the leaves. Both the front and back of the leaves of the plant protection UAV did not meet the requirements of disease and pest control with a low spray amount of 20/cm². The liquid deposition of mist sprayer concentrated in the middle and lower canopy (61.1%), and while for the UAVs, it concentrated in the upper canopy (43.0%). The proportion of the deposition in the canopy was higher than that of the UAVs (48.6%), but the deposition capacity of mist sprayer in the upper canopy was insufficient, accounting for only 17%. The research shows that, compared with UAV, caterpillar mist sprayer is more suitable for the pest control of lower and middlein canopy, at the same time, the high density of droplets cover also has obvious advantages when spraying fungicide. UAV is more suitable for the external tidbits pest control of upper mango canopy, such as thrips, anthrax. According to the experimental results, a stereoscopic plant protection system can be built up in which can use the advantages of both caterpillar mist sprayer and UAV to achieve uniform coverage of pesticide in the mango tree canopy.

Key words: smart mango orchard, misting machine, plant protection unmanned aerial vehicle, droplet deposition distribution uniformity, pest control

中图分类号:

S435

李扬帆, 何雄奎, 韩冷, 黄战, 何苗. 地面弥雾机与六旋翼植保无人机在芒果冠层中雾滴沉积性能对比[J]. 智慧农业(中英文), 2022, 4(3): 53-62.

LI Yangfan, HE Xiongkui, HAN Leng, HUANG Zhan, HE Miao. Comparison of Droplet Deposition Performance Between Caterpillar Mist Sprayer and Six-Rotor Unmanned Aerial Vehicle in Mango Canopy[J]. Smart Agriculture, 2022, 4(3): 53-62.

参考文献

1	柯佑鹏. 浅析RCEP下海南芒果产业发展的挑战及出路[J]. 今日海南, 2022(3): 50-51.
2	岑艳喜. 芒果主要病虫害的发生及防治初探[J]. 南方农业, 2019, 13(9): 11-12.
2	CEN Y. Preliminary study on occurrence and control of main diseases and insect pests in mango[J]. South China Agriculture, 2019, 13(9): 11-12.
3	叶潇潇. 芒果主要病虫害的发生与防治[J]. 农业灾害研究, 2015, 5(9): 7-10.
3	YE X. Occurrence and control of mango fruit main diseases and pests[J]. Journal of Agricultural Catastrophology, 2015, 5(9): 7-10.
4	邢楚明, 韩冬银, 李磊, 等. 蓟马在芒果园田间的时空动态[J]. 环境昆虫学报, 2017, 39(6): 1258-1265.
4	XING C, HAN D, LI L, et al. Spatio-temporal dynamics of thrips in mango orchard[J]. Chinese Journal of Environmental Entomology, 2017, 39(6): 1258-1265.
5	尹平发. 海南芒果病虫害防治技术[J]. 特种经济动植物, 2021, 24(7): 47-48.
5	YIN P. Technology of mango disease and insect pest control in Hainan[J]. Special Economic Animals and Plants, 2021, 24(7): 47-48.
6	何雄奎. 我国植保无人机喷雾系统与施药技术[J]. 农业工程技术, 2018, 38(9): 33-38.
7	朱晓锋, 王明, 徐兵强, 等. 核桃园植保无人机作业参数优选[J]. 植物保护, 2020, 46(4): 25-32.
7	ZHU X, WANG M, XU B, et al. Optimization of unmanned aerial vehicle (UAV) operation parameters in walnut orchards[J]. Plant Protection, 2020, 46(4): 25-32.
8	WANG C, LIU Y, ZHANG Z, et al. Spray performance evaluation of a six-rotor unmanned aerial vehicle sprayer for pesticide application using an orchard operation mode in apple orchards[J]. Pest Management Science, 2022, 78(6): 2449-2466.
9	MENG Y, SU J, SONG J, et al. Experimental evaluation of UAV spraying for peach trees of different shapes: Effects of operational parameters on droplet distribution[J]. Computers and Electronics in Agriculture, 2020, 170: ID 105282.
10	WANG C, HERBST A, ZENG A, et al. Assessment of spray deposition, drift and mass balance from unmanned aerial vehicle sprayer using an artificial vineyard[J]. Science of The Total Environment, 2021, 777: ID 146181.
11	陈盛德, 兰玉彬, 周志艳, 等. 小型植保无人机喷雾参数对橘树冠层雾滴沉积分布的影响[J]. 华南农业大学学报, 2017, 38(5): 97-102.
11	CHEN S, LAN Y, ZHOU Z, et al. Effects of spraying parameters of small plant protection UAV on droplets deposition distribution in citrus canopy[J]. Journal of South China Agricultural University, 2017, 38(5): 97-102.
12	刘德江, 龚艳, 王果, 等. 果园航空喷雾的农药沉积分布比较[J]. 江苏农业科学, 2018, 46(6): 207-211.
13	王昌陵, 何雄奎, 曾爱军, 等. 基于仿真果园试验台的植保无人机施药雾滴飘移测试方法与试验[J]. 农业工程学报, 2020, 36(13): 56-66.
13	WANG C, HE X, ZENG A, et al. Measuring method and experiment on spray drift of chemicals applied by UAV sprayer based on an artificial orchard test bench[J]. Transactions of the CSAE, 2020, 36(13): 56-66.
14	何雄奎. 中国精准施药技术和装备研究现状及发展建议[J]. 智慧农业(中英文), 2020, 2(1): 133-146.
14	HE X. Research progress and developmental recommendations on precision spraying technology and equipment in China[J]. Smart Agriculture, 2020, 2(1): 133-146.
15	何雄奎. 改变我国植保机械和施药技术严重落后的现状[J]. 农业工程学报, 2004(1): 13-15.
15	HE X. Improving severe draggling actuality of plant protection machinery and its application techniques[J]. Transactions of the CSAE, 2004(1): 13-15.
16	周良富, 薛新宇, 周立新, 等. 果园变量喷雾技术研究现状与前景分析[J]. 农业工程学报, 2017, 33(23): 80-92.
16	ZHOU L, XUE X, ZHOU L, et al. Research situation and progress analysis on orchard variable rate spraying technology[J]. Transactions of the CSAE, 2017, 33(23): 80-92.
17	张佳琛, 邓巍, 张燕. 恒压变量喷雾技术研究现状[J]. 农机化研究, 2015, 37(2): 257-260.
17	ZHANG J, DENG W, ZHANG Y. Status quo on research of constant pressure and variable-rate spraying technology[J]. Journal of Agricultural Mechanization Research, 2015, 37(2): 257-260.
18	PETERSON D L, HOGMIRE H W. Tunnel sprayer for dwarf fruit-trees[J]. Transactions of the ASAE, 1994, 37(3): 709-715.
19	李龙龙, 何雄奎, 宋坚利, 等. 基于变量喷雾的果园自动仿形喷雾机的设计与试验[J]. 农业工程学报, 2017, 33(1): 70-76.
19	LI L, HE X, SONG J, et al. Design and experiment of automatic profiling orchard sprayer based on variable air volume and flow rate[J]. Transactions of the CSAE, 2017, 33(1): 70-76.
20	ESCOLà A, ROSELL-POLO J R, PLANAS S, et al. Variable rate sprayer. Part 1—Orchard prototype: Design, implementation and validation[J]. Computers and Electronics in Agriculture, 2013, 95: 122-135.
21	闫成功, 徐丽明, 袁全春, 等. 基于双目视觉的葡萄园变量喷雾控制系统设计与试验[J]. 农业工程学报, 2021, 37(11): 13-22.
21	YAN C, XU L, YUAN Q, et al. Design and experiments of vineyard variable spraying control system based on binocular vision[J]. Transactions of the CSAE, 2021, 37(11): 13-22.
22	宋淑然, 陈建泽, 洪添胜, 等. 果园柔性对靶喷雾装置设计与试验[J]. 农业工程学报, 2015, 31(10): 57-63.
22	SONG S, CHEN J, HONG T, et al. Design and experiment of orchard flexible targeted spray device[J]. Transactions of the CSAE, 2015, 31(10): 57-63.
23	范道全, 张美娜, 潘健, 等. 基于靶标叶面积密度参数的变量喷雾控制系统开发与性能试验[J]. 智慧农业(中英文), 2021, 3(3): 60-69.
23	FAN D, ZHANG M, PAN J, et al. Development and performance test of variable spray control system based on target leaf area density parameters[J]. Smart Agriculture, 2021, 3(3): 60-69.
24	OSTERMAN A, GODE?A T, HO?EVAR M, et al. Real-time positioning algorithm for variable-geometry air-assisted orchard sprayer[J]. Computers and Electronics in Agriculture, 2013, 98: 175-182.
25	孙诚达, 柳长鼎. 风送喷雾雾滴冠层穿透模型构建及应用[J]. 农业工程学报, 2019, 35(15): 25-32.
25	SUN C, LIU C. Construction and application of droplet canopy penetration model for air-assisted spraying pattern[J]. Transactions of the CSAE, 2019, 35(15): 25-32.
26	. 农药喷雾机(器)田间操作规程及喷洒质量评定 [S]. 北京: 中国标准出版社, 2008.
27	. 农业航空作业质量技术指标.喷洒作业 [S]. 北京: 中国民用航空局, 1995.

[1]	资乐, 臧禹, 黄俊浩, 包瑞峰, 周志艳, 肖汉祥. 植保无人机飞防助剂与杀虫剂的混配方式对二化螟防治效果影响研究[J]. 智慧农业(中英文), 2021, 3(3): 52-59.
[2]	唐青, 张瑞瑞, 陈立平, 李龙龙, 徐刚. 植保无人机施药数值建模关键技术与验证方法研究进展[J]. 智慧农业(中英文), 2021, 3(3): 1-21.
[3]	王昌陵, 何雄奎, BONDSJane, 齐鹏, 杨苡, 高万林. 不同飞行参数下八旋翼植保无人机下洗气流场对雾滴沉积分布特性的影响[J]. 智慧农业（中英文）, 2020, 2(4): 124-136.
[4]	朱航, 李宏泽, 黄钰, 于海涛, 董云哲, 李君兴. 施药技术参数对旋翼植保无人机喷雾特性的影响[J]. 智慧农业, 2019, 1(3): 113-122.